Our country has always attached importance to environmental protection, for dust control, emission standard boilers are made specific provisions. In recent years, the tiny dust particles on the flue gas has been some progress in recovery. But have little effect on the FGD. At present the only manufacturers of filter dust, smoke does not eliminate the sulfides. Hebei letter Environmental FRP Products Factory Kay basis with universities and research departments on a combination of, after years of hard work and development, production of XKBTC series dust collector, desulfurization of flue gas desulfurization dust in one. BCT Series FRP FGD wet dust precipitator is a desulfurization unit. It is specifically designed to meet the national boiler soot emission concentration of pollutants in the atmosphere of a standard class areas (less than 50mg / NM3) standard design and manufacture of flue gas purification equipment. Using today's advanced spray fluidized bed with the best combination of complementary technologies to achieve a variety of desulphurization and dust removal mechanism of interaction, so that the water film desulfurization dust formed within a stable rapid movement of water and air bubbles, air flow sufficient interference fit - water mixture suspension layer. It differs from the cyclone dust desulfurization desulphurization water filtration and water film is a highly efficient desulfurization and dust removal device. Its main features are as follows: 1, the desulfurization dust for steam or hot water boiler smoke and dust and desulfurization effect have reached the national emission standards. 2, the product result tight, with good sealing properties and corrosion resistance, long life and low cost. 3, the device is small and light weight. Reassembling easy to install, easy to implement multi-level dust. 4, the use of advanced spray water film technology to improve the efficiency of the spray, the amount of recycled water savings. 5, the amount and concentration of SO2 in the flue gas fumes, fluctuations adaptability, adapt 0.9-8% of the sulfur content of the coal. 6, the product is wet, water and gas full exchange, adsorption tiny dust particles down through the mist, water discharged through the use of closed loop precipitation. Conservation of water resources on the one hand, on the other hand to prevent water from entering sewers, causing secondary pollution. Adding an aqueous solution of lime in the water, making the water PH value greater than 6 can be satisfied with the desulfurization effect. 7, with advanced dust removal performance, solve the shortcomings of the cyclone dust collector applications operates on the principle of the boiler load reduction caused by lower collection efficiency. With lime desulfurization, rich sources. If using digest ash (powder) can be directly added to the sedimentation tank. Water circulation so that the use of lime solution containing, low cost.